保定市电加热器厂

1. The installation of the circulating pipe is easy to remove the gas in the pipe.

2、循环管路如有泄露，应及时停止运行，修理好后方可使用。

2. If the circulation pipeline is leaked, it should stop running in time and can be used after repair.

3、电气控制柜应避免积灰，要经常用压缩空气吹扫，保证电气接触良好。

3, electric control cabinet should avoid ash accumulation, often use compressed air blowing, to ensure that electrical contact is good.

4、应经常检查电热管接点、熔断器、仪表、电接点压力表及继电器。

4, we should often check the electric heat pipe contact, fuse, instrument, electric contact pressure gauge and relay.

5、由于导热油电加热器采用精密仪表，故运输、安装时严禁剧烈震动。

5. Due to the use of precision instruments for heat conduction oil and electric heaters, severe vibration is strictly prohibited in transportation and installation.

6、导热油电加热器应经常检查测温仪表，并进行定期计量，防止测温节点热阻增加，造成温度不准而误操作。

6, heat conduction oil and electricity heater should always check the temperature measuring instrument and carry out regular measurement to prevent the heat resistance of the temperature measuring node to increase, and cause the inaccurate operation of the temperature.

7、用户应定制详细的操作规程和定期保养检修制度，操作人员应非常熟悉和掌握本设备操作要领。

7, the user should customize the detailed operating procedures and regular maintenance and maintenance system, and the operator should be very familiar with and master the operation essentials of this equipment.

8、用户长期使用，更换电热元件后，接线一定要可靠，加热器进行试漏，防止导热油渗漏、电线接触不良，打火引起火灾事故。

8, users long-term use, after replacing the electric heating element, the wiring must be reliable. The heater will leak test to prevent the leakage of heat conducting oil and the bad contact of wires, and cause a fire accident by fire.

9、导热油电加热器导热油不应超过最高允许温度。一般在使用半年后每隔2～3个月，将导热油取样化验一次，并注意不同油品不要混用。

9. The heat conduction oil of the heat conduction oil and electric heater should not exceed the maximum allowable temperature. Generally, every 2~3 months after the use of half a year, the heat conduction oil is sampled and tested once, and the different oils should not be mixed.

10、对导热油电加热器在运行中发现油温上升困难时，应立即查核管道是否畅通，阀门是否弄错，过滤器器是否堵塞等现象，要进行排除后才能使用，对过滤器要进行定期拆洗。

10, for the thermal oil heater in oil temperature rise during operation difficulty, should immediately check whether the valve pipe is smooth, the filter is blocked by the phenomenon, should be excluded before use, regular cleaning of filters should be carried out.